Liberty Sport 2WD L4-2.4L VIN 1 (2002)
Skid Plate: All Technical Service Bulletins
Front End - Creak Noise
NUMBER: 13-001-01
GROUP: Frame
DATE: Sep. 07, 2001
SUBJECT:
Creak-Like Sound Coming From Front End Of Vehicle
OVERVIEW:
This bulletin involves the adjustment, or possible replacement, of the front skid plate.
MODELS:
2002
(KJ)
Liberty
NOTE:
THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO AUG. 31, 2001 (MDH 0831XX).
SYMPTOM/CONDITION:
The vehicle may exhibit a creak-like sound that originates from the front end of the vehicle.
This creak-like sound may occur when the vehicle operator either applies the brakes at slow speeds, or when a slow speed turn is made (similar to what
may occur during a parking lot maneuver). In a few instances the condition has been described as a pop-like sound.
The technician may erroneously diagnose the cause of this condition as a brake or suspension component.
DIAGNOSIS:
Determine if the left forward corner of the front skid plate has made contact with the front crossmember. Refer to the figure below for illustration of the
possible contact area. If evidence of contact is present perform the Repair Procedure.
PARTS REQUIRED:
REPAIR PROCEDURE:
1.
Loosen, but do not remove, the four skid plate attaching bolts.
2.
Slide the front skid plate as tar to the right (passenger side) of the vehicle as is possible. While holding the skid plate in place, tighten the four
attaching bolts.
