Wrangler L4-150 2.5L VIN P MFI (1993)
2.
Raise tank into position and connect the seven skid plate mounting nuts and tighten to 12 ft. lbs. Remove the transmission jack.
3.
Connect vent hoses and fuel filler hose.
4.
Install fuel filler neck shroud and push clips in to secure (Figure 1).
5.
Lower vehicle from hoist.
6.
Refill fuel tank and inspect all hoses and connections for leaks.
7.
Connect negative battery cable.
Owner Letter
SAFETY RECALL -- Fuel Tank Sending Unit Gasket
Dear Chrysler Corporation Vehicle Owner:
This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.
It has been determined that a defect which relates to motor vehicle safety exists in some 1987 through early-1994 model Jeep(R) Wrangler vehicles
equipped with a plastic fuel tank. The fuel tank sending unit gasket may crack, resulting in the potential for fuel leakage. In some cases, this may cause
an underbody fire which could be hazardous to vehicle occupants.
Your vehicle, identified on the enclosed form, is affected. For this reason we ask that you arrange for service to correct the condition without delay. The
service and required parts as described in this letter will be provided free of charge.
To correct the condition, your dealer will replace the fuel tank sending unit gasket. The work will take about one and one-half hours to complete.
However, additional time may be required depending on how dealer appointments are scheduled and processed. To obtain this free service:
Contact your dealer to schedule a service appointment.
Take the enclosed Owner Notification Form with you at the time of your appointment and give it to your dealer. The form identifies the vehicle and the
service that is required.
If you have any problem obtaining the needed repair, please call the Chrysler Customer Center, toll free, at 1-800-853-1403. A representative will assist
you in getting your vehicle repaired.
We regret any inconvenience which this action may cause you. However, we are concerned about your safety. If your dealer fails or is unable to remedy
this defect without charge and within a reasonable time, you may submit a written complaint to the Administrator, National Highway Traffic Safety
Administration, 400 Seventh Street, S.W., Washington, D.C. 20590, or call the Toll Free Auto Safety Hotline at 1-800-424-9393. (Washington D.C. area
residents may call 366-0123.)
Thank you for your attention to this important matter.
