Wrangler 2WD V6-3.8L (2008)
Clutch Disc: Customer Interest
M/T - Squeaking Sound From the Clutch
NUMBER: 06-001-08
GROUP: Clutch
DATE: June 14, 2008
THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 06-004-07, DATED OCTOBER 26, 2007. ALL REVISIONS ARE
HIGHLIGHTED WITH **ASTERISKS** AND INCLUDES A REVISED CLUTCH DISC PART NUMBER.
SUBJECT:
Squeak-Like Sound Due To Manual Transmission Clutch Disc
OVERVIEW:
This bulletin involves the replacement of the manual transmission clutch disc.
MODELS:
2007 - 2008
(JK)
Wrangler
NOTE:
This bulletin applies to Wrangler vehicles equipped with a 3.8L engine and manual transmission (sales codes EGT and DEH respectively), built on
or before June 5, 2008 (MDH 0605XX).
SYMPTOM/CONDITION:
The customer may experience a squeak-like sound from the transmission clutch. This sound will occur when there is a change in engine torque. The
squeak-like sound can be heard most often during: clutch engagement, acceleration (tip-in), and/or deceleration maneuvers. This condition may be due to
the clutch disc internal components.
DIAGNOSIS:
If the customer experiences the above condition, and the condition is isolated to the clutch, then perform the Repair Procedure.
PARTS REQUIRED:
NOTE:
ONLY the clutch disc requires replacement.
REPAIR PROCEDURE:
1.
Replace the clutch disc:
a.
Refer to TechCONNECT for detail transmission Service Information repair procedures. From the "Service Info tab select: 21 -
Transmission and Transfer Case > Manual Transfer Case - NSG370 > Removal and Installation.
b.
Refer to TechCONNECT for detail clutch disc Service Information repair procedures. From the "Service Info tab select: 6 - Clutch > Disc -
Clutch > Removal and Installation.
POLICY:
Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:
