Rio L4-1.5L (2001)
onto intake manifold.
18.
Install fuel distributor retaining bolts, torque to 15-17 lb.ft. (20-23 Nm).
19.
Reattach injector harness retainers.
20.
Install new flexible fuel line by pushing onto fittings until a click is heard, pull gently to test.
Note:
End of line with colored dots goes toward fuel distributor.
21.
Reinstall air cleaner and engine cover in reverse order of removal.
22.
Turn ignition key on to cycle fuel pump, check fuel distributor for leaks, start engine and check again for leaks.
23.
Install SC036 Campaign Completion Label onto bulkhead above master cylinder.
Note:
The fuel pressure test port was intentionally left off the new fuel distributor. Use fuel pressure test adapter "D" to test fuel pressure at the quick
disconnect located at the bulkhead end of the new flexible fuel line.
FOR CALIFORNIA, MASSACHUSETTS, VERMONT; AND MAINE DEALERS:
VEHICLE EMISSION RECALL - PROOF OF CORRECTION CARD
A Vehicle Emission Recall - Proof of Correction card must be filled out for all vehicles registered in California, Massachusetts, Vermont, and Maine.
California, Massachusetts, Vermont, and Maine residents who own an affected vehicle will be required to possess a Vehicle Emission Recall - Proof of
Correction card as evidence of voluntary service campaign completion when they apply for vehicle registration renewal.
WHAT TO DO WITH THE CARD:
Each customer whose vehicle is registered in California, Massachusetts, Vermont, and Maine must be given a completed Vehicle Emission Recall -
Proof of Correction card after the voluntary service campaign has been completed.
Note:
This card MUST be completed by the Dealership's Service Manager using a permanent ink pen. A fine point pen is recommended. When filling in
the information, copy the information directly from the vehicle, NOT the repair order. ALL INFORMATION MUST BE PRINTED AND NEAT.
DO NOT COMPLETE THE CARD UNLESS THE SERVICE CAMPAIGN WORK IS COMPLETED!
