Freelander (LN) V6-2.5L (2004)
Engine Control Module: All Technical Service Bulletins
Engine Controls - MIL ON/DTC's P0606/P0102
No: 19/02/05/NAS
FGN 310-002
Ref:
Issue: 1
Date: 10 November 2005
Throttle Body Electrical Connector
Contamination
AFFECTED VEHICLE RANGE:
Freelander (LN) All
SITUATION:
MIL ILLUMINATES AND VEHICLE GOES INTO "LIMP-HOME" MODE
A customer may report a concern that the "Service Engine Soon" (MIL) warning lamp illuminates and the vehicle goes into "Limp Home" mode. Codes
P0606 or P0102 may be discovered upon investigation. The throttle body electrical connector may be contaminated or have a poor connection.
RESOLUTION:
INSTALL NEW LINK HARNESS TO THROTTLE BODY
NOTE:
Fault code P0102 is related to the MAF sensor, and in this instance it is flagged as a result of the throttle issue. DO NOT carry out any repairs on the
MAF sensor unless the code reappears after road testing the vehicle.
Should a customer report the MIL and "limp-home" symptoms with codes P0606 and P0102 stored and with the possibility of codes P1141, P1142,
P1628, P1629, P1636, P1637, P1638, P1639, P1677, P1687 and P2070, install a new link harness to the throttle body electrical connector. Follow the
Repair Procedure outlined below.
PARTS INFORMATION:
YMQ501850..........Link harness Qty 1
DDW WARRANTY CLAIMS:
NOTE:
Repair procedures are under constant review, and therefore times are subject to change; those quoted here must be taken as guidance only. Always
refer to DDW to obtain the latest repair time.
DDW requires the use of causal part numbers. Labor only claims must show the causal part number with a quantity of zero.
Normal warranty policy and procedures apply.
REPAIR PROCEDURE
REPLACE THROTTLE BODY CONNECTOR LINK
NOTE:
GTR lookup sequence is as follows:
GTR Home > NAS > Service Information/ LN
Freelander/2004 > Workshop Manuals > Freelander
from 2001 MY - Service Procedures > Bookmark "86-1
Charging and Starting" > Link "86.15.01 Battery"