Range Rover (LP) V8-4.6L (2001)
Power Seat Drive Gear: Customer Interest
Interior - Front Seat Fore/Aft Rocking
No:
76/01/02/NAS
Ref:
Issue:
1
Date:
02/22/02
Front Seat "Rock"
AFFECTED VEHICLE RANGE:
Range Rover (LP)
XA410287 - 1A459560
SITUATION:
EXCESSIVE FREE PLAY IN FRONT SEAT
The customer complains of fore and aft "rocking" of the complete seat during acceleration or braking.
The condition can occur on either the LH or RH seat. Free play within the power operated seat height adjustment mechanism may be determined to be
the cause.
RESOLUTION:
REPLACE SEAT CUSHION MOTOR/GEARBOX ASSEMBLIES
Where a customer complaint of excessive seat movement is confirmed, replace the seat cushion height and tilt motor/gearbox assemblies.
PARTS INFORMATION:
HSB000010
Kit - memory seat motors
Qty 1
^
NPN
Roll pin
Qty 2 included in kit
^
NPN
Spring clip
Qty 2 included in kit
WARRANTY CLAIMS:
78.70.89/34
Time 0.60 hrs.
Exchange seat assembly motors
FAULT CODE: G
Normal warranty policy and procedures apply.
Material allowance is included in labor operation.
REPAIR PROCEDURE
REPLACE SEAT MOTORS
WARNING:
Refer to the WSM section covering SRS and observe the cautions and warnings there before removing the seat from the vehicle.
NOTE:
Before disconnecting the power supply to the seat, use the seat controls to raise the seat to its highest position and tilt fully forward.
1.
Remove affected seat from the vehicle.