Navigator 2WD V8-5.4L (2007)
Headliner: All Technical Service Bulletins
Interior - Gap Between Headliner and Sunroof Panel
TSB 07-22-3
11/12/07
GAP/FIT - HEADLINER TO ROOF OPENING PANEL
FORD:
2007-2008 Expedition
LINCOLN:
2007-2008 Navigator
ISSUE
Some 2007-2008 Expedition and Navigator vehicles equipped with a roof opening panel may experience customer concerns with the fit/gap between the
headliner and roof opening panel.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
1.
Check the fit of the roof opening panel to headliner (Figure 1).
a.
If there is a gap or poor fit between roof opening panel and headliner or the roof opening panel is not covering all the outlying areas of the
headliner, go to Step 2.
b.
If no gap is present, this TSB does not apply, follow Workshop Manual, Section 501-17.
2.
Use a sofi pick or equivalent to lift the roof opening panel weatherstrip over the headliner.
3.
Finesse and smooth the headliner material to the backing of the headliner if needed.
4.
Reposition, finesse and smooth the roof opening panel weatherstrip so it covers the gap or poor fit area of the headliner. The glue that is on the
headliner backing will then adhere to the headliner material keeping it in place and the repositioning of the weatherstrip will repair the concern.
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION
DESCRIPTION
TIME
072203A
2007-2008
0.2 Hr.
Expedition/Navigator:
Follow The Service
Procedure To Correct The
Condition
