Navigator 2WD V8-5.4L (2007)
14.
Remove the condenser.
15.
Remove the original desiccant cartridge plug and 0-rings and discard.
16.
Install a new desiccant cartridge, plug w/ 0-rings, snap ring, and cap.
NOTE
IF THE RECEIVER DRIER CARTRIDGE IS NOT AVAILABLE, REPLACE THE CONDENSER ASSEMBLY.
17.
Install the condenser
18.
Install the headlamp assembly per WSM, Section 417-01.
19.
Charge system with correct amount of R134a and leak test and evaluate the system for proper operation. Run at least 30 minutes. If pulley, clutch
and coil are damaged, replace per WSM.
^
22 oz. - Front A/C
^
33 oz. - With Auxiliary A/C
NOTE
COMPONENTS OF THE ROTUNDA 1/2" DSL AC FILTER ADAPTER KIT ARE A SMALL SUBSET OF THE A/C FLUSHING ADAPTER
KITS 219-00074 AND 219-00024. PURCHASE OF THE TWO LARGER KITS WILL PROVIDE ADAPTERS FOR THE ENTIRE F/L/M
VEHICLE LINES
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION
DESCRIPTION
TIME
