Navigator 2WD V8-5.4L DOHC VIN R (2001)
2.
If leakage/compression check indicates a valve train concern, per valve train diagnostics in WSM, Section 303-00, replace cylinder head and cam
assembly, pipe plugs and timing chain tensioner, per procedure outlined in WSM, Section 303-01.
3.
If cylinder leakage and compression tests are inconclusive, perform misfire diagnostic, per TSB 05-22-8.
NOTE
DO NOT TRANSFER SPARK PLUGS. INSTALL NEW SPARK PLUGS IN REPLACEMENT CYLINDER HEAD AND CAM ASSEMBLY.
NOTE
THE ENGINE MISFIRE CONCERN IS TYPICALLY EXHIBITED ON THE LEFT HAND CYLINDER HEAD AND RARELY ON THE RIGHT
HAND CYLINDER HEAD. UNLESS CONFIRMED, THE RIGHT HAND CYLINDER HEAD SHOULD NOT BE REPLACED AS AN "EXTRA
MEASURE" SERVICE PRECAUTION.
NOTE
THE REPLACEMENT CYLINDER HEAD WILL NOT IMPROVE OR REDUCE ENGINE HORSEPOWER OR TORQUE ABOVE
ADVERTISED LEVELS.
Parts Block
OTHER APPLICABLE ARTICLES: 05-22-08
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
OPERATION
DESCRIPTION
TIME
MT060513
Claim Labor As Actual
Actual
Time Or Use SLTS
Time
Operation If Available
DEALER CODING
CONDITION
BASIC PART NO.
CODE
6049
42
Disclaimer
Technical Service Bulletin # 06-5-13
Date: 060320
Engine - MIL ON/Multiple Misfire Codes Set/Low Power
TSB 06-5-13
03/20/06
ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE
CODE (DTC) P0301, P0302, P0303, P0304, P0305,
P0306, P0307, P0308, AND P0316.
FORD:
2003-2004 Mustang, Mustang
LINCOLN:
1999-2004 Navigator
2002-2003 Blackwood
