mazda Workshop Repair Guides

Mazda Workshop Service and Repair Manuals

DPFE Sensor - MIL ON/DTC P1405 Set|Page 816 > < DPFE Sensor/EGR Tube - MIL ON/DTC P1405 Set|Page 810
Page 1
background image

Pressure Feedback Exhaust Sensor: All Technical Service Bulletins
DPFE Sensor - MIL ON/DTC P1405 Set

Bulletin No.: 003/98
Issued: 04/08/98
Revised: 12/31/98

Category
F (01)

Applicable Model/s
1995-96 B-3000

Subject
MIL ILLUMINATION WITH DTC P1405
NO DRIVEABILITY PROBLEMS

BULLETIN NOTE

^

This bulletin supersedes F003/98 dated 04/08/98. The WARRANTY INFORMATION has been revised.

APPLICABLE MODELS
1995 - 96 B3000

DESCRIPTION

The Malfunction Indicator Lamp (MIL) may illuminate. The vehicle will not exhibit any driveability concerns. Diagnostic Trouble Code (DTC) P1405
may also be stored in the Powertrain Control Module (PCM) continuous memory.

These symptoms are caused by exhaust pulsation in the Differential Pressure Feedback EGR (DPFE) reference hose on the exhaust manifold side
(upstream). This pulsation causes the DPFE sensor voltage to fluctuate outside the calibrated range resulting in the DTC.

To correct this concern, the DPFE (up-stream) reference hose has been modified (longer, molded and "J" shaped) to reduce exhaust pulsation.

Customers complaining of the MIL illumination should have the vehicle inspected and if necessary, have a modified reference hose installed.

REPAIR PROCEDURE

1.

Verify concern.

2.

Check that the upstream reference hose is securely connected and not plugged.

3.

Perform EEC-V Self Test and normal diagnostic troubleshooting according to section F of the workshop manual.

^

Repair as necessary.

4.

If no trouble codes other than P1405 can be found, replace the reference hose with a modified molded reference hose.

NOTE:

^

Do not attempt to modify the molded replacement hose.

^

If the modified upstream hose was installed on a previous repair also replace the EGR tube.

5.

List the date, dealer number, service bulletin number and summary of modifications on the "Authorized Modification Decal":

^

Install decal on the radiator support.

NOTE:

This information advises technicians of changes made to the EGR system, if future repairs are necessary.

6.

Verify repair.

DPFE Sensor - MIL ON/DTC P1405 Set|Page 816 > < DPFE Sensor/EGR Tube - MIL ON/DTC P1405 Set|Page 810