E 350 4MATIC Wagon (211.287) V6-3.5L (272.972) (2007)
Windshield Washer Pump: Service and Repair
AR82.35-P-6002TA Remove/Install Windshield Washer System Pump
Shown For Equipment With Code (600a) Headlamp Cleaning System Or Code (614) Bi-xenon Headlamp Unit
1
Disconnect ground cable of battery
DANGER:
-
Risk of death. Death may result if vehicle slips or topples from the lifting platform.
-
Align vehicle between the columns of the hydraulic hoist and position the four support plates below the hoist support points specified
by the vehicle manufacturer.
2
Lift vehicle on lifting platform.
3
Remove right front wheel
-
Wheel bolt:130 N.m
4
Remove rear fender liner in right front fender
5
Disconnect electrical connectors (1)
6
Disconnect electrical connector (2) on HCS pump (M5/2)
7
Disconnect the washer fluid hose from the windshield washer fluid pump (M5/1)
-
Only applies where the windshield washer fluid pump (M5/1) is removed.
NOTE: Collect washer fluid which flows out.
8
Disconnect the washer fluid hose from the rear-end door washer fluid pump (M5/3)
-
Only applies where the rear-end door washer fluid pump (M5/3) is removed.
NOTE: Collect washer fluid which flows out.
9
Disconnect electrical connector (8) from washer fluid reservoir (6)