E 55 AMG Sedan (211.076) V8-5.5L SC (113.990) (2003)
Technical Service Bulletin # 2005110001F
Date: 060501
Recall - SBC Wire Harness Modifications
Campaign No. 2005110001, May 2006
FILE:
SERVICE: GROUP 00 OF SERVICE INFORMATION BINDER
PARTS: GROUP I OF INFORMATION - PARTS & ACCESSORIES BINDER
Revision History
TO: ALL MERCEDES-BENZ CENTERS
SUBJECT:
MODEL 211, MODEL YEAR 2003-2006
MODEL 219, MODEL YEAR 2006
MODEL 230, MODEL YEAR 2003-2005
INSTALLATION OF GROUND WIRES AND BRACKET TO SBC WIRING HARNESS
This Recall Campaign has been initiated because DCAG has determined that on the affected vehicles (see VIN range) the SBC brake system may shift to
the hydraulic back up mode due to the loosening of the ground wire harness connection over time. Dealers will install a bracket and replace the ground
wire.
Note:
This recall campaign is divided into two separate Procedures:
I
MODELS 211/219
INSTALLATION OF GROUND WIRES AND BRACKET TO SBC WIRING HARNESS (PAGES 3-19)
II
MODEL 230
INSTALLATION OF GROUND WIRES AND BRACKET TO SBC WIRING HARNESS (PAGES 20-34)
Note:
With the launch of this campaign, 211 and 230 vehicles subject to last year's SBC Recall Campaign No. 2004050014 that have not been repaired to
date have been excluded from last year's campaign and will no longer appear in VMI as an "Open" campaign. All vehicles subject to last year's SBC
recall, both "Open" and "Closed" will be campaigned under this year's SBC campaigns.
Please review the Effective Serial Number Chart located on the following page.
Included is a sample copy of a letter which owners of the affected vehicles will receive.
Prior to performing this Recall Campaign:
^
Please check VMI to insure the vehicle is involved and to determine if the vehicle has been previously repaired.
^
Please review the entire Recall Campaign bulletin.
Approximately 194,828 vehicles are involved.