Merkur Xr4ti L4-140 2.3L SOHC Turbo (1985)
Evaporator Drain Tube: All Technical Service Bulletins
A/C - Condensate Leaks Into Passenger Compartment
AIR CONDITIONING - CONDENSATE LEAKS INTO PASSENGER COMPARTMENT
Article No. 88-22-4
MERKUR:
1985-87 XR4Ti 1988-89 SCORPIO
ISSUE:
Air conditioning condensate that leaks into the passenger compartment may be caused by plugged A/C evaporator drain hose check valves.
The A/C evaporator drain hose check valves should be serviced every 7500 miles (12000 kilometers) as called out in the scheduled
maintenance section of the owner guide.
FIGURE 12
ACTION:
If service is required, check and clean the A/C evaporator drain hose check valves. Refer to the following procedure for service details.
NOTE:
THE EVAPORATOR CHECK VALVES ARE IN THE ENGINE COMPARTMENT INSIDE THE PREFORMED DRAIN HOSES,
FIGURE 12.
1.
Before removing the evaporator drain hoses, mark them (right and left) to assist in reinstallation.
2.
Remove the drain hoses from the evaporator drain tubes by pulling them off.
3.
Remove the check valves from the ends of the drain hoses.
4.
Remove all debris from the check valves and drain hoses.
5.
Inspect the check valves and drain hoses for damage. Replace as required.
NOTE:
THE RUBBER FLAP INSIDE THE CHECK VALVE MUST BE SNUG BUT HAVE ENOUGH CLEARANCE AT THE CENTER
ATTACHING PIN TO ALLOW IT TO ROTATE FREELY.
6.
Reinstall the check valve with the rubber flap pointing downward in the drain hose.
PART NUMBER
PART NAME
CLASS
E5RY-19858-A
Check Valve - Right Hand
C
E5RY-19858-C
Check Valve - Left Hand
C
OTHER APPLICABLE ARTICLES: 87-6-3
WARRANTY STATUS:
"INFORMATION ONLY"