Eclipse L4-1997cc 2.0L DOHC (1991)
Technical Service Bulletin # EMR92006R2
Date: 920201
Recall - Oxygen Sensor Replacement
NO.:
EMR-92-006 Revision 2
DATE:
February, 1992
MODEL:
1991-1992 Eclipse Turbo
SUBJECT:
1991 - 1992 2.0L TURBOCHARGED
FEDERAL ECLIPSE EMISSION RECALL
This bulletin supercedes EMR-92-006 Revision dated January 1992, which should be discarded.
PURPOSE
This bulletin provides a detailed procedure for inspection and repair of the emission control system on certain turbocharged 1991 and 1992 2.0L
turbocharged Federal Emission Certified Eclipse models. A letter has been sent to all owners of the affected vehicles informing them to return their
vehicles to their Mitsubishi Motors dealer to have the engine serviced. A copy of this letter is shown on Page 6 of this bulletin.
Please note that the customer is not to be charged for the repairs covered by this bulletin. To achieve the desired results, the procedure MUST be
followed EXACTLY as described in this bulletin.
IMPORTANT NOTICE
All dealerships MUST perform all steps described in this bulletin. Incomplete repairs will lead to emissions non-compliance and obvious customer
dissatisfaction. The Environmental Protection Agency (EPA) will survey the results of this campaign several months after starting. If incomplete repairs
or non-compliance is found, another recall could be ordered or other action undertaken by EPA.
Furthermore, the EPA may consider failure to properly perform emission recall procedures as tampering, which may subject the servicing dealer to a fine
of up to $25,000 per vehicle. Confirm that you are using the proper Technical Service Bulletin repair procedures and service kits for the vehicle model
year and engine size that you are working on. Service procedures are different even though some vehicles may look alike.
AFFECTED VEHICLES
This procedure applies to 1991 and 1992 2.0L turbocharged Federal Emission Certified Eclipse models equipped with manual or automatic
transmissions without limitation as to mileage. It does not apply to any other models.
NOTE:
1992 turbocharged Eclipse models produced from September 6,1991, beginning with VIN 4A3CT64U8NE030682, have been corrected
during vehicle production. Therefore, perform this recall on 1992 models built prior to this VIN.
REQUIRED OPERATIONS
1.
Replace the Oxygen Sensor.
2.
Clear any diagnostic codes stored in the MPI system's ECU using the Multi-Use Tester.
PARTS INFORMATION
Oxygen sensor:
MD188208
Required on each claim. No other parts are allowed to be claimed.
WARRANTY INFORMATION
Submit as Recall Claim type "C", Menu option "E-5" on your Diamond Network System. Do NOT submit as "W" claims!
Required Operation
Labor Operation Code:
C9207TXX
Time allowance:
0.2 hr.
Note:
The "O" in the above labor code is the number ZERO.
