Titan 2WD V8-5.6L (VK56) (2004)
Clockspring Assembly / Spiral Cable: Customer Interest
Interior - Steering Wheel Vibration At 29 Or 58 MPH
Classification: ST04-001
Reference: NTB05-111
Date: November 21, 2005
2004 TITAN AND ARMADA; VIBRATION IN STEERING WHEEL AT 29 OR 58 MPH
APPLIED VEHICLE(S):
2004 Titan (A60)
2004 Armada (TA60)
IF YOU CONFIRM
The steering wheel exhibits an up and down movement under the following conditions:
^ during steady state (constant speed) driving
^ with a minor vehicle load (traveling up hill)
^ vibration peaks at vehicle speeds of either 29 or 58 MPH
^ the wheel /tire balance is ok.
ACTION
Install the contact plate listed in this bulletin.
PARTS INFORMATION
CLAIMS INFORMATION
IMPORTANT:
The purpose of ACTION (above) is to give you a quick idea of the work you will be performing. You MUST closely follow the entire Service Procedure
as it contains information that is essential to successfully completing this repair.
SERVICE PROCEDURE
1. Use the procedure in the Service Manual to remove the Driver Air Bag module.
Caution:
^ Do not attempt to repair or replace damaged direct-connect SRS component connectors. If a driver air bag direct-connect harness connector is
damaged, the spiral cable must be replaced.
^ Before servicing the SRS, turn ignition switch OFF, disconnect both battery cables and wait at least 3 minutes.