Alero L4-144 2.4L DOHC VIN T SFI (2000)
Cabin Ventilation Duct: Customer Interest
Air Inlet - Heater Blower Inoperative/Interior Floor Wet
File In Section: 08 Body and Accessories
Bulletin No.: 01-08-57-003
Date: September, 2001
TECHNICAL
Subject:
Heater Blower Inoperative or Water on Passenger Floor
(Install Sealing Strip)
Models:
1999-2001 Oldsmobile Alero
1999-2001 Pontiac Grand Am
Condition
Some customers may comment that water drips on the front passenger floor or that the heater blower is inoperative in cold weather.
Cause
This condition may be caused by water entering the fresh air inlet to the HVAC case due to poor sealing of the air inlet screen to the fresh air inlet
opening.
Correction
1.
Open the hood and remove the windshield wiper arms.
2.
Remove the air inlet screen panel and replace the foam seal. Refer to illustration above.
3.
Inspect the cowl drain holes located at each end of the cowl. They should be open and free of debris.
4.
Reinstall the air inlet screen.
5.
Make sure the lip on the lower windshield lace sits on top of the air inlet screen panel when installing the air inlet screen.