Aurora V6-214 3.5L VIN H SFI (2001)
Fluid Line/Hose: Customer Interest
A/T Cooler Fitting - Fluid Leaks
File In Section: 07 - Transmission/Transaxle
Bulletin No.: 01-07-30-015
Date: April, 2001
TECHNICAL
Subject:
Leak at the Transmission Cooler Quick Connect Fitting Interface to the Lower Transmission Cooler Line (Replace the Quick Connect Type Fitting at the
Transmission Case cover and Replace the Lower Cooler Line to the Radiator with an Inverted Flare Type Connector and Line)
Models:
2001 Cadillac DeVille, Eldorado, Seville
2001 Oldsmobile Aurora
with Hydra-Matic 4T80-E Automatic Transmission (RP0 MH1)
Condition
It has been noted that the subject vehicles may have a small transmission fluid leak from the quick connect fitting at the case cover. The leak is actually
noticed between the transmission case cover quick connect cooler fitting and the cooler line connection interface.
Cause
This specific leak is a severe cold temperature related condition. This interface will only leak for a brief moment when the vehicle is shifted into Drive
and/or Reverse, and at a very low sump temperature. It has been determined that replacing the leaking quick connect fitting and/or lower cooler line with
a new quick connect fitting and/or lower cooler line of the same type will not fix a leak experienced under the severe cold conditions described above.
Correction
Verify that the vehicle being worked on is a 2001 model, and has a 4T80-E (RP0 MH1) automatic transmission with quick connect style cooler fittings.
Replace the quick connect type transmission case cover cooler fitting with an inverted flare type fitting. Replace the lower cooler line with the threaded
type fitting listed below for the vehicle being serviced.
Parts Information
Parts are currently available from GMSPO.
Warranty Information
For vehicles repaired under warranty, use the table as shown.
