Horizon/TC3 L4-105 1720cc 1.7L SOHC VIN A 2-bbl (1982)
Engine Control Module: All Technical Service Bulletins
Engine - Slow Acceleration/Bucking on Deceleration
Models
1982 & 1983 1.7L Omni, Horizon 2- Dr.. & 4-Dr. Models - Auto. & Manual Transmissions With Federal or California Emission systems
Subject
Driveability Improvement & Flat Acceleration After Slowing Down & Bucking During Deceleration
Index
FUEL
Date
March 28, 1983
No.
14-10-83
SYMPTOM/CONDITION
This service procedure resolves two driveability problems outlined below.
The first driveability condition is flat and slow acceleration after slowing down for a few seconds. This symptom is known as "lean ramping". The
second condition is a bucking or jerking motion during closed throttle deceleration or partially closed throttle deceleration.
PARTS REQUIRED
Order
See
Model
Orig.
Replace.
Note
Year
Market
Trans.
ESA/EFC
ESA/EFC
Below
1982
Federal
Manual
5213438
4318113
(1)
1982
Federal
Auto.
5213437
5213890
-
1983
Fed. &
Manual
5213438
4318113
(1)
Calif.
NOTE (1): Replacing this part number module will change the basic timing specification from 20~ BTDC to 12~ BTDC. Reset basic timing to 12~
BTDC with the vacuum hose to the ESA/EFC disconnected and plugged.
Must be ordered separately:
1 - Authorized Modification Label
PN 4275086
REPAIR PROCEDURE
1.
Remove original ESA/EFC module and install appropriate module from model application chart above.
2.
After installation of replacement ESA/EFC module on 1982 automatic transmission models it will be necessary to check and reset basic timing per
the adjustment chart below if required.
1982 1.7L Automatic Transmission Federal Emission System With ESA/EFC PN 5213890
Check and reset basic timing, if necessary, per original VECI label specification.
1982 1.7L Manual Transmission Federal Emission System With ESA/EFC PN 5213892
Reset basic timing to 120 BTDC. Reset curb idle speed and hot fast idle speed to original VECI label specifications (see Note on page 1).
1983 1.7L Manual Transmission Federal and California Emission System With ESA/EFC PN 5213892
Reset basic timing to 12~ BTDC. Reset curb idle and hot fast idle RPM per original VECI label specification (see Note on page 1).