Neon L4-2.0L VIN C (1997)
Technical Service Bulletin # 07-04-98
Date: 980417
Cooling System - Fan ON Continuously/Overheats
NO: 07-04-98
GROUP: Cooling
DATE: Apr. 17, 1998
SUBJECT:
Vehicle Overheats (Radiator Fan Inoperative) Or Radiator Fan Runs Continuously
THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 07-07-97 DATED FEBRUARY 20, 1998 WHICH SHOULD BE NOTED IN
THE 1997 TECHNICAL SERVICE BULLETIN MANUAL (PUBLICATION NUMBER 81-699-98004). THE REVISION PROVIDES A NEW PART
NUMBER FOR THE RADIATOR FAN RELAY. THE CHANGE IS HIGHLIGHTED WITH ASTERISKS.
MODELS:
1997 - 1998 (PL) Neon
NOTE:
THIS BULLETIN APPLIES TO VEHICLES BUILT AT TOLUCA ASSEMBLY PRIOR TO SEPTEMBER 11, 1997 (MDH 0911XX). TOLUCA
ASSEMBLY IS DESIGNATED BY A "T" IN THE ELEVENTH POSITION OF THE VEHICLE IDENTIFICATION NUMBER.
SYMPTOM/CONDITION:
Vehicle overheats or radiator fan continues to run.
DIAGNOSIS:
Actuate the radiator fan relay using the DRB III. If the radiator fan does not come on or fan runs continuously, perform the Repair Procedure.
PARTS REQUIRED:
1
05293157AA
Jumper Wire With Diode, Radiator Fan
**1
04707286
Relay, Radiator Fan**
2
06015756
Tie Strap
POLICY: Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:
Labor Operation No:
08-65-12-92
0.3 Hrs.
FAILURE CODE: P8 - New Part
Repair Procedure
This bulletin involves installing a radiator fan jumper wire assembly into the headlamp and dash wiring harness, and replacing the solid state relay.
1.
Raise the hood and disconnect the negative battery cable.
