Voyager L4-153 2.5L SOHC Turbo (1989)
6.
Mount the controller inside the left front fender. Install and tighten the two mounting screws removed in Step 3.
7.
Reinstall the battery using Service Manual procedures.
8.
Install the air cleaner duct onto the controller.
Completion Reporting and Reimbursement
Claims for vehicles which have been serviced must be submitted by DIAL dealers on the DIAL System. Non DIAL dealers may submit WROs. Claims
submitted will be used by Chrysler to record recall service completions and provide dealer payments.
Enter only one VIN per claim on a WRO. Fill in the labor operation number and time allowance and write on the WRO "Emissions Recall # 450 --
Engine Controller Replacement". Do not enter other service claims on the same WRO.
Use the following labor operation number and time allowance:
Labor Operation
Time
Number
Allowance
Remove and replace Single
08450182
0.3 Hours
Module Engine Controller
Add the cost of the new engine controller and the applicable dealer allowance to your claim.
Parts Return
Removed controllers must be returned to the Warranty Material Return Center.
Note:
See Warranty Policy and Procedure Manual, Chapter 6, Subsection H, for complete recall claim processing and material return instructions.
Vehicle Not Available
If a vehicle is not available for this service for a known reason, let us know by filling out the pre-addressed Vehicle Disposition Form portion of the
Owner Recall Notification Form or describe the reason on a postcard and mail to:
Chrysler Motors 416-15-19 Recall Coordination P.O. Box 1919 Detroit, Michigan 48231-9986
Following the above procedures will expedite the processing of your claim.
If you have any questions or need assistance in completing this action, please contact your Zone Service Office.
Owner Letter
EMISSIONS RECALL --
1989 VEHICLES WITH 2.5 LITER TURBOCHARGED ENGINE AND CALIFORNIA EMISSIONS SYSTEM
Dear Chrysler Motors Vehicle Owner:
Recently we learned that a small number of 1989 model year vehicles equipped with a 2.5L turbocharged engine, manual transmission, and California
emissions control system were built with an incorrect engine controller. Models affected include Dodge Daytona, Shadow, and Caravan; Plymouth
Sundance and Voyager; and Chrysler LeBaron and LeBaron GTS. The condition could result in hydrocarbon and carbon monoxide levels which exceed
the limits allowed by the California Emissions Standards. For this reason, we are asking you to return your vehicle -- identified by the Vehicle
Identification Number on the enclosed form -- to your dealer for replacement of the controller. This service will be provided free of charge.
The needed instructions have been sent to all Chrysler-Plymouth and Dodge dealers in California. The service will not hurt your engine performance or
fuel economy. Your dealer is ready to serve you now. To obtain this service:
^
Contact your dealer as soon as possible to make an appointment for the free service. We request that you contact the dealer who sold you the
vehicle. However, if necessary, the service can be arranged for through any ChryslerPlymouth or Dodge dealer. Provide the model name of
your vehicle and tell the dealer that you want Recall Number 450 repair service performed. The dealer will then be able to order the correct
replacement parts prior to your appointment.
^
Take the enclosed Owner Recall Notification Form with you at the time of your appointment and give it to your dealer. The form identifies
the vehicle and recall for which service is required.
^
The dealer will replace the engine controller. The service will take about one-half hour.
