Grand AM V6-3300 3.3L (1992)
Steering Gear: All Technical Service Bulletins
Steering Wheel - Noise at Right Dash Area When Turning
File In Section: 3 - Steering/Suspension
Bulletin No.: 43-32-11
Date: November, 1994
Subject:
Crunch Noise from Right Side Dash Area when Turning Steering Wheel (Replace Steering Grommet)
Models:
1991-94
Buick Skylark
1991-94
Chevrolet Beretta, Corsica, Cavalier
1991
Oldsmobile Cutlass Calais
1992-94
Oldsmobile Achieva
1991-94
Pontiac Grand Am, Sun bird
VIN Breakpoints:
1994 vehicles built prior to the following VIN numbers:
J Car: R7574194 (Pontiac Lordstown)
R7293501 (Chevrolet Lordstown)
All "J" cars assembled in Ramos
L Car: RY250151
N Car: RM573861
RM037851
RC777220
RC285393
Condition
Some owners may comment on a brief crunch noise originating from the right side dash area as the steering wheel is being turned. This noise would be
more noticeable when the wheel has been turned full right, then turned back to the left. This noise may be more noticeable when the vehicle is stopped or
moving slowly during parking maneuvers. Also, this noise would only occur during cold temperatures below 4O°F (4°C).
Cause
The rubber grommets retaining the steering gear may flex and exhibit a crunch noise.
Correction
Install a new steering grommet, P/N 26047683, on the right side. The new grommet has a softer compound to allow more compliance without crunching.
Parts Information
Parts are currently available from GMSPO.
Warranty Information
For vehicles repaired under warranty, use:
Labor Operation
Labor Time
E9745
0.5 hr.
