pontiac Workshop Repair Guides

Pontiac Workshop Service and Repair Manuals

All Technical Service Bulletins for Wastegate: > < Turbocharger Oil Feed Pipe Replacement|Page 6663
Page 1
background image

Wastegate: Customer Interest
Engine Controls - MIL ON/DTC P0299/P0234 Set

TECHNICAL

Bulletin No.: 09-06-93-004

Date: July 21, 2009

Subject: Intermittent MIL/Check Engine Light On, DTC P0299 or P0234 Set (Adjust Turbocharger Wastegate Actuator)

Models:

2008-2009 Chevrolet Cobalt, HHR
2008-2009 Pontiac Solstice GXP
2008-2009 Saturn SKY Redline
2008-2009 Opel GT
2008 Daewoo G2X
with Engine RPO LNF and LDK (Europe)
Please Refer to GMVIS

Condition

Some customers may comment that the SES light is on. Upon inspection, you may find DTC P0299 (Turbocharger Engine Underboost) or P0234
(Turbocharger Engine Overboost) set.

Cause

This condition may be caused by a mis-adjusted wastegate.

Correction

Note

The wastegate adjustment is sometimes a very fine process. When adjusting the wastegate, only small adjustments should be made. Loosen one nut at a
time and only adjust the nut one turn at a time; then tighten the other nut against the shaft and test drive to verify. This may have to be performed several
times to achieve the desired boost level. To ensure proper adjustment, the vehicle should be at full operating temperature when testing. The vehicle will
be very hot and may need to cool between adjustments. Too large of an adjustment can cause repeat DTCs. 

Adjust the turbocharger wastegate. Refer to Turbocharger Wastegate Actuator Adjustment in SI.

Troubleshooting Tips for DTC P0299 - Turbocharger Engine Underboost

To increase boost, adjust the nuts (in) towards the actuator; in essence making the shaft shorter. 

Troubleshooting Tips for DTC P0234 - Turbocharger Engine Overboost

To reduce boost, adjust the nuts (out) towards the end of the shaft; in essence making the shaft longer.

Warranty Information

For vehicles repaired under warranty, use the table above.

Disclaimer

All Technical Service Bulletins for Wastegate: > < Turbocharger Oil Feed Pipe Replacement|Page 6663