Sunfire L4-2.2L VIN F (2002)
Important:
Fill the transmission to the amount specified. Too much lubricant will cause the fluid to leak from the vent. Not enough fluid will defeat the purpose
of this bulletin.
7.
Fill the transmission with 2.4L (2.6 qts) of Saturn Manual Transmission Lubricant P/N 21018899. DO NOT USE THE RED VENT CAP TO
FILL.
8.
Re-install the fill plug.
Tighten
Tighten the fill plug to 38 N.m (28 lb ft).
Diagnosis for Noise # 2
This noise, commonly referred to as gear rattle, can be induced by lugging the engine in any gear, but is usually most noticeable in first or second gear.
While the noise is occurring, if you press lightly on the clutch pedal without releasing the clutch, the noise will be reduced or eliminated.
Repair for Noise # 2
Do not attempt to repair this noise. This is a characteristic of the vehicle and any vehicle equipped with a manual transmission can be made to make a
similar noise. Driving at slightly higher engine RPM levels will reduce this noise.
Parts Information
Parts are currently available from GMSPO.
Warranty Information
For vehicles repaired under warranty, use the table as shown.
DISCLAIMER