Vibe L4-1.8L VIN L (2003)
Window Seal: Customer Interest
Body - Front/Rear Door Glass Area Wind Noise
Bulletin No.: 06-08-64-024
Date: July 11, 2006
TECHNICAL
Subject:
Wind Noise From Front or Rear Door Glass Area (Replace Front Door Glass Weatherstrip)
Models:
2003-2005 Pontiac Vibe
Condition
Some customers may comment on a wind noise from the front or rear door glass area.
Cause
This condition may be caused by the weatherstrip not sealing properly.
Correction
Replace the front or rear door glass weatherstrip following the procedure below.
Front Door Glass Weatherstrip
1.
Lower the window.
2.
Remove the front door trim. Refer to Trim Panel Replacement - Side Front Door in SI.
3.
Remove the water deflector.
4.
Unclip and remove the inner mirror garnish trim from the door.
5.
Remove the window run channel weatherstrip from the guide channel.
6.
Clean the guide channel of any debris.
7.
Partially raise the glass and install the window channel weatherstrip in to the guide channel in the door.
8.
Install the window channel weatherstrip into the corners of the window opening before installing the center part of the strip.
9.
Install the inner mirror garnish trim to the door.
10.
Install the water deflector.
