9000 Hatchback L4-2290cc 2.3L DOHC Turbo EFI (1994)
9. Bend down the two upper retaining lugs and pull forward the ashtray holder. Unplug cables from cigarette lighter and ashtray light.
10. Pull the steering wheel as far forward as possible.
11. Remove steering wheel. See group 6, section 641.
12. Remove the protective covers from the steering column.
13. Remove covers and remove instrument panel screws.
14. Cars with manual gearbox: Engage reverse. Remove screw under gear lever gaiter. Cars with automatic transmission: Remove plug and screw
securing gear selector cover.
15. Remove the centre facia vent and air duct.
-
Standard and standard with A/C:
Detach the control panel by pressing in the four securing lugs and pulling it into the cabin. Detach the air distributor rod, the temperature
control damper gear and all connectors (make sure that the temperature control is in position 0).
-
ACC:
Pull forward the ACC control module. Unplug the connector and ground cable. Cut the cable tie securing the wiring.
16. Detach the outer facia vent from the instrument panel.
17. Unplug connectors from switches and clock. Mark connectors to make it easier to refit them. Lift off the instrument panel.
18. Dismantle the selector switch. Mark connectors to make it easier when refitting them.
19. Remove screws from combined instrument.
20. Remove acoustic insulation panels from under the facia. Remove panels from center console.
21. Remove left-hand and right-hand floor ducts.
22. Remove screws securing left-hand and right- hand side defroster ducts.
23. Cut the cable tie securing the wiring harness to the left-hand air duct (right-hand drive cars in right-hand air duct).
24. Unplug loudspeaker connections.
25. Remove screws securing the instrument panel and lift it out.
26. Detach cable tie from heater housing so that the electrical distribution box can be lifted down to the floor of the car.
