9000 Hatchback L4-2290cc 2.3L DOHC Turbo EFI (1994)
Windshield: Customer Interest
Windshield - Whistling Noise
CATEGORY
Body
SECTION
8
PAGE
100
ISSUE
01/95-0539
CODE
841
Subject:
Correcting Whistling Noise From Windshield
Application:
9000 Models
Supersedes PSI 10/93-0383
A customer complaint of a whistling noise coming from the center, upper part of the windshield can be corrected by fastening double-sided tape between
the upper part of the windshield trim and the roof panel as outlined below. This complaint is usually generated at higher speeds and is more likely to
occur during hot weather. If the windshield has been replaced on a car and it has been incorrectly mounted, this could also contribute to the complaint.
Cars Affected:
9000 Models
Parts:
Double-sided tape 74 97 357*
*5 pieces required per car - 10 pieces supplied
Teroson cleaner FL (1 liter) 30 15 815
or equivalent degreasing product
Action:
If this procedure is done in conjunction with a windshield change, the tape should not be divided (see point 3) but should be used as it is on the card.
1.
Lift the trim from the upper part of the windshield. See Figure 1.A.
2.
Clean the edge of the roof panel and the surface of the trim where it makes contact with the panel using Teroson cleaner FL or equivalent
degreasing product.
