900 S Sedan V6-2498cc 2.5L DOHC (1995)
Radio/Stereo: All Technical Service Bulletins
Radio - Interference On the AM Band
CATEGORY
Electrical
SECTION
3
PAGE
94
ISSUE
06/96-0692
CODE
931
Subject:
Correcting a Customer Complaint of AM Radio Interference
Application:
1994-1996 900
Supersedes 06/96-0691
To correct customer complaints of AM radio interference on 1994-1996 900 models, it may prove necessary to install extra grounding straps on the
vehicle. Be sure that the ignition cables, and the antenna and antenna cable are in good condition first. Perform an engine ground voltage drop test with
the electrical system under load. If there is a voltage drop greater than 0.1 V, replace the engine ground cable. Then follow the directions below to
correct this complaint.
Cars Affected:
1994-1996 900 models
Parts:
16" bonding strap such as NAPA/Belden 711699 (3) [sourced locally]
8" bonding strap such as NAPA/Belden 710899 (1) [sourced locally]
8 mm x 13 mm bolt (1) [sourced locally]
8 mm lock washer (1) [sourced locally]
Clip Nut (1)
86 01 916
Hexagon screw (1)
79 83 000
Speed clip with screw (1) [sourced locally]
Black 14 gauge wire [sourced locally]
Terminal
91 20 957
Ring terminal (1) for 14 gauge wire [sourced locally]
Ring terminal (1) for 10 gauge wire [sourced locally]
Action:
1.
Raise the car on a lift.
2.
Using a 10 mm nut, secure one end of a 16 in. braided ground strap to the main battery ground at the transmission.
Note:
