ION L4-2.2L VIN F (2004)
Sunroof / Moonroof Switch: All Technical Service Bulletins
Sunroof/Interior Mirror - Inoperative
File in Section: 08 - Body and Accessories
Bulletin No.: 04-08-45-006
Issue Date: June, 2004
Subject:
Sunroof Inoperative and/or Inside Rearview Mirror Electrical Functions Inoperative (Replace Fuse and Install New Sunroof Switch)
Models Affected:
2003-2004 Saturn ION
(Sedan - Built Up To and Including VIN Breakpoint 4Z190767)
(Coupe - Built Up To and Including VIN Breakpoint 4Z191744)
Attention: Technician
Condition:
Some customers may comment on the sunroof being inoperative. They may also comment that the inside rearview mirror electrical functions will not
work.
Cause:
Activation of the sunroof switch may cause the internal circuitry of the sunroof switch to route the sunroof power feed to ground, which may cause the
sunroof fuse to open.
Correction:
Install a new 15 amp sunroof fuse in the Integrated Body Control Module (IBCM). Also install a new sunroof switch, P/N 22687360. Replace the
sunroof switch using the procedure in this bulletin.
Service Procedure:
Sunroof Control Switch Replacement Removal
Important:
After replacing the sunroof switch and fuse, verify that the fuse does not open by cycling the switch. If it does open, refer to "Circuit Testing (SI
Document ID # 427510) and Wiring Repairs (SI Document ID # 897944)" in the Wiring System section located in the 2003 Saturn ION Service
Manual.
1.
Use a small, flat-bladed tool to disengage the clips located at the front and rear of the sunroof control switch.
2.
To remove the sunroof control switch, rotate the switch down and to the left.
