saturn Workshop Repair Guides

Saturn Workshop Service and Repair Manuals

Sunroof - Water Leaks Onto Headliner|Page 10037 > < Sunroof - Water Leaks Onto Headliner
Page 2
background image

3.

Water test vehicle in the water leak location described by the customer. (Refer to "Waterleaks" in the General Information section of the
appropriate model year Body/Repair service manual [1996-1999] or Windnoise/Waterleaks/Appearance section of Body/Electrical Vol. I service
manual [2000-2001].)

^

If water leak occurs in front area of sunroof module, refer to "Sunroof Drain Hose Clamps," "Sunroof Housing Front Drain Hoses," Sunroof
Module Front Drain Hose Grommets," and "Reseal Front of Sunroof Module" in this bulletin.

^

If water leak occurs in rear area of sunroof module, refer to "Sunroof Drain Hose Clamps," "Sunroof Housing Rear Drain Hoses," and "Reseal
Rear of Sunroof Module" in this bulletin.

^

If water leak occurs in any area(s) other than the headliner, refer to "Diagnosis and Repair" under Water Leaks in the General Information
section of the appropriate model year Body/Repair service manual.

4.

Once water leak has been repaired, install headliner.

^

On 1996 - 1999 model year vehicles, refer to "Headliner - Coupe" or "Headliner - Sedan" installation procedure in the Vehicle Interior
Systems section of the appropriate model year Body/Repair service manual.

^

On 2000 - 2001 model year vehicles, refer to "Headliner - Coupe" or "Headliner - Sedan" installation procedure in the Interior Trim section of
the appropriate model year S-Series Body/Electrical Volume II Service Manual.

Sunroof Module Drain Hose Clamps - All Models

A water leak at sunroof module drain hose locations where they attach to sunroof module can be identified by watching around edges of sunroof module
from inside vehicle while water test stand is running. Allow ample time when water testing for water leak to occur.

^

If water leaks between the hose and sunroof module drain, refer to the following procedure.

^

If water is not leaking between hose and sunroof module drain, refer to the other procedures in this bulletin.

1.

Inspect for clamps on all drain hoses of sunroof module.

^

If sunroof module drain hose clamps are present, tighten clamps and retest for water leak.

^

If sunroof module drain hose clamps are not present, continue to next step.

2.

Remove all drain hoses from sunroof module.

3.

Feed sunroof module drain hose clamps (P/N 01626260) onto hoses.

4.

Push hoses back onto sunroof module so that they fully seat.

5.

Tighten clamps.

Sunroof - Water Leaks Onto Headliner|Page 10037 > < Sunroof - Water Leaks Onto Headliner