SW L4-1.9L DOHC VIN 7 (1993)
^
If water is not present in the immediate area, refer to "Waterleaks" in the "General Information" section of the appropriate year
"Body/Collision Repair Service Manual" for the vehicle being worked on.
3.
Open door and lower door glass to the full-down position.
NOTICE:
Care should be taken not to over bend the door frame which could impair door glass operation or door closing. It is better to adjust the door frame in
small increments to achieve the required fit.
4.
Grasp the upper door frame at top of frame and carefully pull the door frame inboard along the entire top of door frame.
5.
After a slight adjustment has been made, proceed to the next Step and perform the "Dollar Bill" test.
6.
Dollar bill test:
a.
Place a dollar bill or similar size piece of paper between the front side door (primary) weatherstrip and the contact surface of the space
frame, then close the door.
IMPORTANT:
Make sure to leave the window in the full-down position. This equalizes pressure inside the vehicle when the door is closed and allows the dollar bill
(or piece of paper) to stay in the correct position.
b.
Slowly withdraw the dollar bill or piece of paper after the door is closed to check the amount of pressure on the front side door (primary)
weatherstrip.
c.
There should be a medium amount of resistance as the dollar bill (or piece of paper) is slowly withdrawn. Continue around the entire upper
door frame.
^
If there is little or no resistance, it indicates there is insufficient contact to form a good seal between the front side door (primary)
weatherstrip and the space frame. Repeat steps 3 through 6, until door frame is correctly adjusted.
^
If there is a medium amount of resistance, proceed to the next step.
7.
After door is properly adjusted, check door glass operation by raising and lowering the door glass. Also, check door operation by opening and
closing the door to make sure it operates correctly.
8.
To verify that the waterleak has been repaired, apply an unrestricted flow of water over the door frame (as explained in step 1 of this bulletin).
^
If waterleak has been repaired, return vehicle to customer.
^
If waterleak is still present and the vehicle is a:
