L-Series Sedan (4 Door) 2WD F4-1781cc 1.8L SOHC (MPFI) (1985)
Headlamp Switch: Technical Service Bulletins
Headlight Switch - Service Parts/Installation
NUMBER 08-27-88
DATE 02-01-88
'85 AND '86 XT VEHICLES FROM 1985 VIN 300001 TO 1986 VIN 324021
SUBJECT:
HEADLIGHT SWITCH SERVICE PARTS
The headlight switch is available as a separate component part from the headlight and sub switch assembly.
Headlight switch component part number 83002GA650 can be used to repair the following headlight and subswitch assemblies:
83002GA240
83002GA242
83002GA260
83002GA250
83002GA252
The headlight switch component part can be ordered through normal parts channels using part number 83002GA650.
INSTALLATION PROCEDURE
1.
Disconnect the negative battery terminal.
2.
Remove the control wing by following the procedure in the applicable Subaru Service Manual.
^
1985 XT vehicles use the 1985 Subaru XT Service Manual section 6-2, pages 40 and 44.
^
1986 XT vehicles use the 1986 Subaru XT Service Manual section 6-2, pages 54 and 58.
3.
Remove the headlight switch component from the left hand control wing.
Note:
Do not remove the sub switch assembly from the control wing.
FIGURE 1
4.
Locate and disconnect the 6-pole (white) female connector and the 21-pole (black) male connector from the column harness and cut the five wires
which connect the headlight component to the 21-pole (black) male connector as shown in figure 1.