4 Runner 2WD V6-4.0L (1GR-FE) (2006)
Sunroof / Moonroof Windguard: All Technical Service Bulletins
Body - Moon Roof Stuck/Improper Operation
T-SB-0289-08
September 9, 2008
Moon Roof Stuck/Improper Operation
Service Category
Vehicle Exterior
Section
Sliding Roof/Convertible
Market
USA
Applicability
TSB SUPERSESSION NOTICE
The information contained in this TSB supersedes TSB No. BO016-06.
^
Applicability has been updated to include 2008 model year 4Runner vehicles.
TSB No. BO016-06 is Obsolete and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before
proceeding.
Introduction
Some customers may experience a moon roof that exhibits improper operation such as:
^
The moon roof does not close from its fully open position (an improper jam protection operation occurs).
^
The moon roof is stuck due to a difference of alignment between the right and left parts of the moon roof.
^
Sliding parts are stuck due to hardened grease.
Perform the following repair procedure to correct these conditions.
Warranty Information
APPLICABLE WARRANTY
^
This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first,
from the vehicle's in-service date.
^
Warranty application is limited to correction of a problem based upon a customer's specific complaint.