Camry Sedan L4-2.4L (2AZ-FE) (2003)
Intake Manifold: All Technical Service Bulletins
Engine - Rattle Noise At Idle/Light Acceleration
T-SB-0034-08
Rev1
April 15, 2008
Intake Manifold Noise
Service Category
Engine/Hybrid System
Section
Intake/Exhaust
Market
USA
Applicability
TSB REVISION NOTICE:
^
May 6, 2009 Rev1:
^
The Introduction and Production Change Information sections have been updated to specify non-PZEV vehicles.
^
Applicable Warranty in the Warranty Information section has been updated.
Any previous printed versions of this service bulletin should be discarded.
The information contained in this TSB supersedes TSB No. EG018-04.
^
Applicable Warranty (California Emission Warranty coverage) has been updated.
TSB No. EG018-04 is Obsolete and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before
proceeding.
Introduction
Some 2002 - 2004 model year non-PZEV Camry vehicles with the 2AZ-FE engine may experience the following condition:
^
A rattle noise from the engine area most noticeable at idle or on light acceleration.
The noise may be caused by the intake air as it flows through the intake manifold. The intake manifold has been modified to improve this condition.
Production Change Information
This TSB applies to vehicles produced BEFORE the Production Change Effective VINs shown.