Matrix FWD L4-1.8L (2ZR-FE) (2010)
Front Steering Knuckle: Service and Repair
Removal
AXLE AND DIFFERENTIAL: STEERING KNUCKLE: REMOVAL
HINT
*
Use the same procedure for the RH side and LH side.
*
The procedure listed below is for the LH side.
1. REMOVE FRONT WHEEL
2. REMOVE FRONT AXLE SHAFT NUT (for 2AZ-FE) See: Transmission and Drivetrain/Drive Axles, Bearings and Joints/Axle Shaft
Assembly/Service and Repair/Removal and Replacement/Removal
3. REMOVE FRONT AXLE SHAFT NUT (for 2ZR-FE) See: Transmission and Drivetrain/Drive Axles, Bearings and Joints/Axle Shaft
Assembly/Service and Repair/Removal and Replacement/Removal
4. SEPARATE FRONT SPEED SENSOR See: Suspension/Ball Joint/Service and Repair/Removal
5. SEPARATE FRONT DISC BRAKE CALIPER ASSEMBLY See: Wheels and Tires/Wheel Fastener/Service and Repair/Front Axle Hub
Bolt/Replacement
6. REMOVE FRONT DISC See: Brakes and Traction Control/Disc Brake System/Service and Repair/Removal and Replacement/Front
Brake/Removal
7. SEPARATE TIE ROD END SUB-ASSEMBLY (for 2WD) See: Steering Gear/Service and Repair/Removal
8. SEPARATE TIE ROD END SUB-ASSEMBLY (for 4WD) See: Steering Gear/Service and Repair/Removal
9. SEPARATE FRONT LOWER SUSPENSION ARM See: Suspension/Ball Joint/Service and Repair/Removal
10. REMOVE FRONT AXLE ASSEMBLY See: Suspension/Wheel Hub/Service and Repair/Front Axle Hub/Removal
11. REMOVE FRONT LOWER BALL JOINT See: Suspension/Ball Joint/Service and Repair/Removal
12. REMOVE FRONT AXLE HUB HOLE SNAP RING See: Suspension/Wheel Hub/Service and Repair/Front Axle Hub/Removal
13. REMOVE FRONT AXLE HUB SUB-ASSEMBLY See: Suspension/Wheel Hub/Service and Repair/Front Axle Hub/Removal
14. REMOVE FRONT DISC BRAKE DUST COVER See: Suspension/Wheel Hub/Service and Repair/Front Axle Hub/Removal
15. REMOVE STEERING KNUCKLE
(a) 2ZR-FE:
(1) Place the front axle hub bearing inner race (outside) on the front axle hub bearing.
(2) Using SST and a press, remove the front axle hub bearing from the steering knuckle.
SST : 09223-15020
SST : 09387-02010
SST : 09950-60010
09951-00640
SST : 09950-70010
09951-07100