Subject:
Time Allowances
Vehicles:
Corsa-B, Tigra, Vectra-B, Omega-B
Condition:
The time allowances and some of the
operational descriptions for the operations listed at the end of this document
were revised and are valid as of 1st June 1998.
Unless especially identified with C, the
time allowances for the main and additional work remain valid and can be found
in the current publications.
|
Model
Line
|
Op.
No.
|
Operation
|
Time
Allow.
|
Code
|
|
|
Corsa-B /
|
J 7940 00
|
MULTEC - Motor for Idle Charge
Control, Replace
|
1.6
|
X14XE/
X16XE
|
C
|
|
Tigra
|
|
TC: 15, 27, 86, 87
|
|
|
|
|
|
|
+: For vehicles with DOHC engine: Throttle body R + R
|
|
|
|
|
|
|
|
|
|
|
|
Vectra-B
|
D 3181 00
|
Evaporator, Remove and Install
|
3.8
|
|
C
|
|
|
|
TC: 04, 72
|
4.2
|
X25XE
|
C
|
|
|
|
+: For X 25 XE engine: Rear Intake Pipe (1-3-5) R + R
|
|
|
|
|
|
|
- : Refrigerant, Drain and Top Up; AC, Evacuate, and Check
for Leaks; Performance Test, Perform
|
|
|
|
|
|
|
|
|
|
|
|
|
|
In addition:
|
|
|
|
|
|
005
|
Additional work for vehicles with
automatic transmission
|
.2
|
|
C
|
|
|
|
|
|
|
|
|
|
J 7001 00
|
Starter, Remove and Install
|
2.5
|
X25XE
|
C
|
|
|
|
TC: 01, 06, 15, 37, 40, 86, 87
|
|
|
|
|
|
|
- : For X 25 XE Engine: Engine R + R (not required)
|
|
|
|
|
|
|
|
|
|
|
|
|
M 0185 00
|
Intermediate Shaft, Replace
|
.3
|
|
C
|
|
|
|
TC: 04, 27, 40
|
|
|
|
|
|
|
- : Steering Wheel, Steering Gear and Steering Column
Assy. R + R (not required)
|
|
|
|
|
Omega-B
|
C 0010 00
|
Windscreen, Remove and Install or
Replace
|
2.4
|
|
C
|
|
|
|
TC: 01, 05, 07, 32, 54, 55, 86, 87
|
|
|
|
|
|
|
+: Engine Bonnet, Det. + Att. ; Screen, Clean
|
|
|
|
|
|
|
|
|
|
|
|
|
D 1021 00
|
Heater, Replace
|
4.9
|
|
C
|
|
|
|
TC: 12, 42
|
|
|
|
|
|
|
+: Instrument Panel, R + R; Coolant, Top Up and Cooling
System, Bleed
|
|
|
|
|
|
|
|
|
|
|
|
|
D 1081 00
|
Resistor for Heater Fan Motor, Replace
|
.5
|
|
C
|
|
|
|
TC: 01, 86, 87
|
|
|
|
|
|
|
|
|
|
|
|
|
D 3079 00
|
Refrigerant Line from Expansion Valve
to Separation Point, Replace
|
.5
|
X25DT
|
C
|
|
|
|
TC: 01, 04, 11, 27, 42
|
|
|
|
|
|
|
- : Refrigerant, Drain and Top Up; AC, Evacuate, Check for
Leaks, Performance Test, Perform
|
|
|
|
|
|
|
|
|
|
|
|
|
D 3079 10
|
Refrigerant Line from Receiver-dryer
to Separation Point, Replace
|
1.9
|
X25DT
|
C
|
|
|
|
TC: 01, 04, 11, 27, 42
|
|
|
|
|
|
|
- : Refrigerant, Drain and Top Up; AC, Evacuate, Check for
Leaks, Performance Test, Perform
|
|
|
|
|
|
|
|
|
|
|
|
|
|
In addition:
|
|
|
|
|
|
001
|
Additional work for vehicles with lower
engine compartment cover
|
.2
|
|
C
|
|
Omega-B
|
D 3079 30
|
Refrigerant Line from Receiver-Dryer
to Compressor, Replace
|
.4
|
X25DT
|
C
|
|
|
|
TC: 01, 04, 11, 27, 42
|
|
|
|
|
|
|
- : Refrigerant, Drain and Top Up; AC, Evacuate, Check for
Leaks, Performance Test, Perform
|
|
|
|
|
|
|
|
|
|
|
|
|
|
In addition:
|
|
|
|
|
|
001
|
Additional work for vehicles with lower
engine compartment cover
|
.2
|
|
C
|
|
|
|
|
|
|
|
|
|
D 3079 40
|
Refrigerant Line from Compressor to
Separation Point, Replace
|
1.0
|
X25DT
|
C
|
|
|
|
TC: 01, 04, 11, 27, 42
|
|
|
|
|
|
|
- : Refrigerant, Drain and Top Up; AC, Evacuate, Check for
Leaks, Performance Test, Perform
|
|
|
|
|
|
|
|
|
|
|
|
|
|
In addition:
|
|
|
|
|
|
001
|
Additional work for vehicles with lower
engine compartment cover
|
.2
|
|
C
|
|
|
|
|
|
|
|
|
|
J 3155 00
|
Oil Pan, Remove and Install
|
2.3
|
V6
engine
|
C
|
|
|
|
TC: 01, 03, 04, 06, 08, 11, 12, 15, 27,
40, 42, 61
|
|
|
|
|
|
|
+: Engine, Hoist, Oil Intake Pipe, R + R. For V6 engine:
Both Oil Pans, R + R
|
|
|
|
|
|
|
- : For V6 engine: Front Axle R + R (not required)
|
|
|
|
|
|
|
|
|
|
|
|
|
|
In addition:
|
|
|
|
|
|
024
|
Additional work for vehicles with lower
engine compartment cover
|
.2
|
|
|
|
|
020
|
Additional work when replacing the oil
pan (Oil Level Sensor, Remove and Install)
|
.1
|
|
|
|
Omega-B
|
J 3163 00
|
Oil Pump, Remove and Install
|
7.3
|
V6
engine
|
C
|
|
|
|
TC: 01, 04, 06, 12, 15, 27, 40, 42, 61
|
|
|
|
|
|
|
|
|
|
|
|
|
|
In addition:
|
|
|
|
|
|
004
|
Additional work for vehicles with AC
|
2.1
|
|
|
|
|
|
|
|
|
|
|
|
N 3005 00
|
Speedometer, Replace
|
1.0
|
|
C
|
|
|
|
TC: 15, 40, 54, 57, 67
|
|
|
|
|
|
|
|
|
|
|
|
|
R 1040 00
|
Fog Lamps, Replace - Both Sides
|
.4
|
|
C
|
|
|
|
TC: 01, 04, 24, 42, 86, 87
|
|
|
|
|
|
|
+: Fog Lamps, Adj.; Tyre Air Pressure, Chk. and Corr. - on
4 Wheels
|
|
|
|
Important:
The specified time allowances do not include the time
allowance for the vehicle set-up of .2 hrs.
For reimbursement of the vehicle set-up time of .2 hrs in
warranty claims, enter the authorisation code ”T” and increase the main
operation time allowance by .2 hrs.
The authorisation code may be used only once per work
order. It may only be used more than once if the workplace and workteam are
changed at the same time.
|
