vauxhall Workshop Repair Guides

Vauxhall Workshop Service and Repair Manuals

Time Allowance > < Excerpt,Circuit Diagram - Motronic 2.8.1

Complaints Table

 

If these complaints should occur, examine the marked test steps more closely.

 

Complaints

 

Engine starts poorly or not at all

 

 

Engine starts but stalls again

 

 

 

Idle problems (engine speed, exhaust)

 

 

 

 

Poor throttle response, transition problems

 

 

 

 

 

Engine misfiring (ignition, injection)

 

 

 

 

 

 

Engine output / top speed too low

 

 

 

 

 

 

 

Fuel consumption too high

 

 

 

 

 

 

 

 

Engine diesels

 

 

 

 

 

 

 

 

 

Engine pings, knocks

 

 

 

 

 

 

 

 

 

 

Engine overheats

 

 

 

 

 

 

 

 

 

 

 

Engine stalls at traffic lights

 

 

 

 

 

 

 

 

 

 

 

 

Telltale illuminates constantly or occasionally

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Possible causes

Test step no. in

F0: DATA LIST

 

·

 

 

 

 

 

 

 

 

 

 

·

BATTERY VOLTAGE

01

·

·

·

 

 

·

·

 

 

 

 

·

TPS SIGNAL, SIM. IDLE POS. SW and SIM. FULL POS. SW

02, 03, 04

 

·

·

 

 

 

 

 

 

 

 

·

INTAKE AIR TEMP.

05

·

 

·

·

 

 

·

 

·

·

 

·

COOLANT TEMP.

06

 

·

·

·

·

·

·

 

 

 

 

·

MASS AIR FLOW S.

07

 

 

 

 

 

·

 

 

·

 

 

·

KNOCK SIGNAL

08

 

 

 

 

 

 

 

 

 

 

 

·

IGN. / INJ. CUTOFF

09

 

 

·

 

 

 

·

 

 

 

 

·

HALL SENSOR

10

 

 

·

 

 

 

 

 

 

 

 

 

VEHICLE SPEED and VEHICLE SP. PULSE

11, 12

 

 

·

 

 

 

·

 

 

 

 

 

A / C INFORMAT. SW

13

 

 

·

 

 

 

·

 

 

 

 

 

A / C COMPRESS. SW

14

 

 

·

 

 

 

 

 

 

 

 

 

PARK / NEUTRAL SW.

15

 

 

 

 

 

 

 

 

 

 

 

·

TORQUE CONTROL

16

·

 

 

·

·

·

·

 

 

 

 

·

IGN. COIL l+4 IGN. COIL 2+5 and

IGN. COIL 3+6

17, 19, 20

·

 

 

 

 

 

 

 

 

 

 

·

ENGINE LOAD SIG. and TPS LOAD SIGNAL

21, 22

·

 

 

 

 

 

 

 

 

 

 

·

FUEL PUMP RELAY

23

 

 

 

 

 

 

 

 

 

 

 

·

A / C CUTOFF RELAY

24

 

 

·

·

 

 

 

·

 

 

 

·

FUEL TANK VENT.

25

 

 

 

·

 

·

 

 

 

 

 

·

INT. MANIFOLD V. 1

27

 

 

 

·

 

·

 

 

 

 

 

·

INT. MANIFOLD V. 2

28

 

 

 

·

 

 

 

 

 

 

 

·

SEC. AIR PUMP REL

29

 

 

 

·

 

 

 

 

 

 

 

·

EGR SOLENOID

30

 

 

Engine starts poorly or not at all

 

 

Engine starts but stalls again

 

 

 

Idle problems (engine speed, exhaust)

 

 

 

 

Poor throttle response, transition problems

 

 

 

 

 

Engine misfiring (ignition, injection)

 

 

 

 

 

 

Engine output / top speed too low

 

 

 

 

 

 

 

Fuel consumption too high

 

 

 

 

 

 

 

 

Engine diesels

 

 

 

 

 

 

 

 

 

Engine pings, knocks

 

 

 

 

 

 

 

 

 

 

Engine overheats

 

 

 

 

 

 

 

 

 

 

 

Engine stalls at traffic lights

 

 

 

 

 

 

 

 

 

 

 

 

Telltale illuminates constantly or occasionally

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Possible causes

Test step no. in

F0: DATA LIST

 

 

 

·

 

 

 

 

 

 

 

 

·

EGR PULSE RATIO

31

 

 

·

 

 

 

 

 

 

 

 

·

EGR POS. FDBK

32

 

 

 

 

 

 

 

 

 

 

 

·

ENGINE TYPE

33

 

 

 

 

 

 

 

 

 

 

 

·

TRACTION CONTROL

34

 

 

 

 

 

 

 

 

 

 

 

·

TRANSM. CODING

35

·

 

 

 

 

 

 

 

 

 

 

·

ENGINE SP. PULSE

36

·

·

·

 

·

·

 

 

 

 

 

·

DESIRED IDLE and ENGINE SPEED

37, 38

 

·

·

·

·

·

·

·

 

 

 

 

DESIRED AIR IDLE and ACTUAL AIR IDLE

39, 40

 

·

·

 

 

 

 

 

 

 

 

 

IDLE AIR CONTROL

41

 

·

·

 

 

 

 

 

 

 

 

 

IAC ADAPT. SLOPE

42

 

·

·

 

 

 

 

 

 

 

 

 

IAC INTEGRATOR

43

 

·

·

 

 

 

 

 

 

 

 

 

IAC BLOCK LEARN

44

 

 

·

·

 

 

·

 

·

 

 

 

02 SENSOR LOOP 1, 02 SENSOR LOOP 2,

02 SENSOR 1 and 02 SENSOR 2

45, 46.47, 48

 

 

·

·

 

 

·

 

·

 

 

 

AIR / FUEL RATIO 1,

AIR / FUEL RATIO 2, 02 INTEGRATOR 1 and 02 INTEGRATOR 2

49, 50, 51, 52

 

 

·

·

 

 

·

 

·

 

 

·

02 BLM IDLE 1 and 02 BLM IDLE 2

53, 54

 

 

 

·

 

 

·

 

·

 

 

·

02 BLM PART 1 and 02 BLM PART 2

55, 56

 

 

 

·

 

·

·

 

·

·

 

 

SPARK ADVANCE

57

 

 

 

·

 

 

·

 

·

·

 

·

KNOCK RETARD

58

·

·

·

·

·

·

·

·

 

 

 

 

INJECTION PULSE

59

 

 

 

 

 

 

 

 

 

 

 

·

CHECK LIGHT

60

 

 

 

 

 

 

 

 

 

 

 

·

DIAG. REQUEST

61

 

 

 

 

 

 

 

 

 

 

 

·

INJECTOR CUTOFF

62

 

 

 

 

 

 

 

 

 

 

 

 

Possible causes

Test step no.

in F5: ACTUATOR TEST

·

 

 

 

·

·

 

 

 

 

 

 

Ignition coil or circuit

01, 02, 03

 

 

 

 

 

 

 

 

 

 

 

·

Telltale

04

 

·

·

 

 

 

 

 

 

 

 

 

Idle speed adjuster

05

 

·

·

 

 

 

 

 

 

 

 

·

Tank vent valve

06

 

 

 

 

 

 

 

 

 

 

 

·

AC cutoff relay

07

 

 

·

 

 

·

 

 

 

 

 

·

Intake manifold switchover valve 1 or 2

08, 09

 

 

·

 

 

 

 

 

 

 

 

·

Exhaust gas recirculation valve

10

 

 

·

 

 

 

 

 

 

 

 

·

Secondary air injection relay

11

·

 

·

 

·

 

 

 

 

 

 

 

Pick - ups / interference pulses

-

·

·

·

·

·

 

·

 

 

 

·

·

Control unit defective

-

 

 

Time Allowance > < Excerpt,Circuit Diagram - Motronic 2.8.1