Eos (1F7) L4-2.0L Turbo (BPY) (2007)
Door Module: All Technical Service Bulletins
Body - Door Window, Sticks or Operates Sporadically
64 07 06
July 30, 2007
2014289 Supersedes T.B. Group 64 number 07-03 dated May 8, 2007 due to window control module software adaptation update using Guided
Functions with Brand CD 77 or above.
Condition
Vehicle Information
Door Window, Sticks or Operates Sporadically without Operators Assistance
After closing a front door, the window may open automatically.
When opening door, the window may stick in the roof pillar seal.
Note:
DO NOT replace the window regulator or window regulator motor for this condition.
DO NOT apply procedure to both sides of the vehicle, unless customer concern is with both sides of the vehicle, and the symptom has been verified.
Technical Background
Note:
DO NOT perform adaptation of door control module in Guided Functions with any Brand CD below 77.
Failure to use Brand CD 77 or higher while performing adaptation may result in door control module failure and possible warranty debit.
Window vibration from closing the door allows the window to chaff against the roof pillar seal - as a result the window reverses.
Short drop travel is insufficient.
Production Solution
Improvement of short drop lowering by 2 mm.
^
From 12/2006, VIN No.: WVWBA71F87V027073
Service
Procedure
Perform adaptation of the door control module(s) using Guided Functions before performing Window Travel Basic Settings.