Golf Mk6 Automatic Air Conditioning System - Climatronic for Right-hand Drive Vehicles
| Climatronic - passenger compartment |
Note| t | Before removing components marked with **, disconnect battery → Electrical system; Rep. gr.27. |
| t | A label indicates the type and quantity of refrigerant used. |
| t | In vehicles with start-stop system, note abort conditions: → Chapter |
| 1 - | Dash panel |
| q | Removing and installing → General body repairs, interior; Rep. gr.70 |
| 2 - | Sunlight penetration photosensor -G107- or sunlight penetration photosensor 2 -G134- |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Function: sunlight penetration photosensor controls temperature flap and fresh air blower depending on light intensity |
| q | Emergency running in event of failure: Climatronic control unit -J255- assumes fixed value |
| q | Removing and installing → Chapter |
| 3 - | Centre vents |
| q | Removing and installing → Chapter |
| 4 - | Right side vent |
| q | Removing and installing → Chapter |
| 5 - | Climatronic control unit -J255- |
| q | The Climatronic control unit -J255- and the operating and display unit for Climatronic air conditioning system -E87- are a single component which cannot be dismantled. |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Removing and installing → Chapter |
| q | Renewing: the basic setting and an adaptation („Compressor first run“) must be carried out in the Guided Fault Finding or in the Guided Functions with the vehicle diagnosis, testing and information system -VAS 5051B- (or later model) → Chapter. |
| 6 - | Right vent temperature sender -G151- |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Removing and installing → Chapter |
| 7 - | Footwell vent on driver side |
| q | Removing and installing → Chapter |
| 8 - | Right temperature flap control motor -V159- |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Removing and installing → Chapter |
| q | Renewing: initiate basic setting using vehicle diagnosis, testing and information system -VAS 5051B- (or later model) → Chapter. |
| 9 - | Front air distribution flap control motor -V426- with potentiometer for front air distribution flap control motor -G642- |
| q | Checking: vehicle diagnosis, testing and information system -VAS 5051B- (or later model) |
| q | Removing and installing → Chapter |
| q | Renewing: initiate basic setting using vehicle diagnosis, testing and information system -VAS 5051B- (or later model) → Chapter. |
| 10 - | Rear vent connection |
| 11 - | Auxiliary air heater element -Z35-** |
| q | Checking → Chapter |
| q | Removing and installing → Chapter |
| 12 - | Baffle plate for heater unit |
| 13 - | Dust and pollen filter |
| q | With activated charcoal filter |
| q | Removing and installing → Chapter |
| 14 - | Connecting piece |
| q | For air duct |
| q | Must be removed for removal of → General body repairs, interior; Rep. gr.68 |
| 15 - | Air duct for right rear footwell |
| q | Removing and installing → Chapter |
| 16 - | Air duct for left rear footwell |
| q | Removing and installing → Chapter |
| 17 - | Connector |
| 18 - | Fresh air blower -V2- with fresh air blower control unit -J126- |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Removing and installing fresh air blower -V2- → Chapter |
| q | Removing and installing fresh air blower control unit -J126- → Chapter |
| 19 - | Footwell vent on front passenger side |
| q | Removing and installing → Chapter |
| 20 - | Heater and air conditioning unit -VX1- |
| q | Removing and installing → Chapter |
| q | Dismantling and assembling → Chapter |
| 21 - | Vent temperature sender -G150- |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Removing and installing → Chapter |
| 22 - | Seal |
| 23 - | Control motor for fresh air and air recirculation flap and air flow flap -V425- |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Removing and installing → Chapter |
| q | Renewing: initiate basic setting using vehicle diagnosis, testing and information system -VAS 5051B- (or later model) → Chapter. |
| 24 - | Left temperature flap control motor -V158- |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Removing and installing → Chapter |
| q | Renewing: initiate basic setting using vehicle diagnosis, testing and information system -VAS 5051B- (or later model) → Chapter. |
| 25 - | Defroster flap control motor -V107- |
| q | Checking: Vehicle diagnosis, testing and information system -VAS 5051B- (or later model). |
| q | Removing and installing → Chapter |
| q | Renewing: initiate basic setting using vehicle diagnosis, testing and information system -VAS 5051B- (or later model) → Chapter. |
