Jetta L4-1.8L Turbo (AWD) (2000)
/Page-1441001.png)
Battery: Technician Safety Information
Warnings and Safety Measures For Lead-Acid Batteries
Warnings And Safety Measures For Lead-acid Batteries
WARNING!
1
-
Keep open flames and sparks away and DO NOT smoke near batteries!
-
Avoid sparks when working with cables and electrical units.
-
Always reinstall battery positive (B+) or negative (-) terminal covers if removed during servicing.
2
-
Always wear eye protection when working with electrolyte!
-
If electrolyte gets into eyes, flush with large quantities of water. Seek medical attention immediately!
3
-
Keep children away from batteries!
4
-
Dispose of batteries properly!
-
Waste batteries must only be disposed of in appropriate waste disposal sites. Refer to local regulations pertaining to battery
disposal
5
-
Never dispose of batteries in household waste!
6
-
Danger of explosion!
-
Batteries produce explosive gasses while being charged.
-
Keep open flames and sparks away and DO NOT smoke near batteries.
-
The battery charger MUST be turned off when connecting or disconnecting the cables at the battery.
-
Battery cell caps must NOT be removed while charging.
-
Ensure that battery is charged in a well ventilated area.
-
Avoid short circuits. Always reinstall battery positive (B+) or negative (-) terminal covers if removed during servicing.
7
-
Read and follow all instructions on battery.
8
-
Battery acid can cause severe burns!
-
When working with electrolyte always wear eye protection, rubber gloves and a suitable apron. If electrolyte is spilled on eyes,
skin, clothing (or painted surfaces), flush at once with large quantities of water.
-
Never tip a battery on edge. Electrolyte can spill from the ventilation openings.
Batteries With Central Gas Venting
Batteries With Central Gas Venting
Batteries with two different styles of central gas venting are installed:
-
Batteries with central gas vent hose
-
Batteries without central gas vent hose
CAUTION!
-
Only new generation batteries with central gas venting are to be installed!
-
For proper function of central venting and flame trap, check vent hose (where applicable) for proper installation. Vent hose must NOT be
disconnected or pinched.
-
Only the use of genuine VW battery cell caps ensures the different battery cover systems are sealed correctly.
-
Only use genuine VW cell caps of the same construction if lost or damaged.
-
Caps must be fitted with an O-ring seal.
