Passat Sedan V6-3.6L (BLV) (2008)
Headlamp Alignment Sensor: Procedures
Vehicle Level Sensors, Servicing
General information
A vehicle level sensor is located on the front axle ( Left Front Level Control System Sensor G78 ) and rear axle ( Left Rear Level Control System Sensor
G76).
The vehicle level sensors are a component of vertical headlamp aim control system. The vehicle level senors transmit a Pulse Width Modulation (PWM)
signal (representing vehicle attitude, load etc.) to Headlamp Range/Cornering Lamp Control Module J745.
In order to generate this PWM-signal, voltage is supplied to the Left Rear Level Control System Sensor G76 via two plus-wires and one Ground (GND)
wire. Voltage is supplied to Left Front Level Control System Sensor G78 via one plus-wire and two Ground (GND) wires.
Vehicle Level Sensors G76 / G78, removing and installing
Left Front Level Control System Sensor G78 removing and installing
Left Rear Level Control System Sensor G76 removing and installing
NOTE: In the event a vehicle level sensor is replaced, the headlamp basic setting be performed in conjunction with checking headlamp aim.