850 T-5R L5-23L Turbo VIN 58 B5234T5 (1995) Air Duct Cable
Air Door Cable: Service and Repair
Air Duct Cable
Adjustment of control wires:
Before adjusting control wires, try adjusting lower attachment of cable to climate control unit.
1. Remove soundproofing.
-
Remove left- or right-hand soundproofing (depending on cable to be adjusted).
2. Disconnect cable sleeve concerned from its clip.
-
Left-hand temperature damper cable (1). Turn left-hand temperature damper to 0. Push lever as far down as it will go and then push cable
sleeve into clip.
-
Right-hand temperature damper cable (2). Turn right-hand temperature damper to 0. Push lever as far down as it will go and then push cable
sleeve into clip.
-
Ventilation and floor/defroster damper cables (3). Set control to DEFROST (12 0'clock position). Push ventilation and floor/defroster levers
to end position and then push sleeves into respective clips.
If this adjustment does not work, the upper cable fittings must be adjusted, go to step 3.
Replace control panel, control cable: