S60 2.4 L5-2.4L VIN 61 B5244S (2001)
Steering Mounted Controls Communication Module: Symptom Related Diagnostic Procedures
Fault-Tracing Information
Fault-tracing information
Condition
-
No PHM DTCs are stored in the Central electronic module (CEM).
-
No DTCs are stored in the Steering wheel module (SWM).
Possible source
-
Open-circuit, short-circuit to supply voltage or short-circuit to ground in the cable.
-
Faulty contact reel.
Fault symptom[s]
-
Steering wheel keypads does not work
Checking Contact Reel
Checking contact reel
Checking the wires and components
Disconnect contact reel from SWM control unit.
Check resistance between B1 and B2. The resistance should be infinite.
Check resistance between B1 and B3. The resistance should be infinite.
Check resistance between B2 and B3. The resistance should be infinite.
Check wire B1 between contact reel 1 for an open circuit as described in Checking wiring and terminals. Permanent fault See: Testing and
Inspection/Component Tests and General Diagnostics/Checking Wiring and Terminals/Checking Wiring and Terminals. Permanent Fault.
Check wire B2 between contact reel 2 for an open circuit as described in Checking wiring and terminals. Permanent fault See: Testing and
Inspection/Component Tests and General Diagnostics/Checking Wiring and Terminals/Checking Wiring and Terminals. Permanent Fault.
Check wire B3 between contact reel 3 for an open circuit as described in Checking wiring and terminals. Permanent fault See: Testing and
Inspection/Component Tests and General Diagnostics/Checking Wiring and Terminals/Checking Wiring and Terminals. Permanent Fault.
Do the necessary corrective action.
Additional information:
-
For information on signals, see Signal specification See: Pinout Values and Diagnostic Parameters/Signal Specification, Steering Wheel Module
(SWM)
-
To connect a test box, see Connecting the breakout box See: Pinout Values and Diagnostic Parameters/Connecting the Breakout Box, Steering
Wheel Module (SWM)
-
To access/replace the contact reel, see Contact reel / steering wheel angle sensor, replacing See: Restraint Systems/Air Bag Systems/Clockspring
Assembly / Spiral Cable/Service and Repair/Removal and Replacement/Contact Reel / Steering Wheel Angle Sensor, Replacing.