S60 T5 L5-2.3L Turbo VIN 53 B5234T3 (2002)
-
Switch off the recirculation function on the dashboard environmental panel so that the air intake opens
-
Find marking (1) in the short end of the air intake (left hand end on left-hand drive cars). Illuminate using a small torch. Mark out the contours
using a light pen
-
Position a drift in the centre of the marking. Carefully tap out the mark. Use a hammer
-
Remove the plastic rectangle
-
Carefully remove the covering from the fan housing. This is to prevent swarf falling down into the fan.
-
Slide the passenger seat as far back as possible
-
Remove the side panel from the centre console. Turn the clip (1) a quarter turn on the centre console side panel. Pull the panel out and back
-
Remove the soundproofing panel. Remove the two screws from the underside of the soundproofing panel. Pull the rear edge of the panel
downwards to release the two clips. Then pull it backwards.
-
Turn the ignition key to position 0
-
Remove the key from the ignition switch (does not apply to cars with automatic gearboxes)
-
Disconnect the battery negative lead.
NOTE: Wait at least five minutes before disassembling the connectors or removing other electrical equipment.
Remove:
