S70 T5 L5-2.3L Turbo VIN 53 B5234T3 (1998)
AW50-42 Transmission
Replacing Transmission Fluid , AW50-42
Note!
Oil grade: Only automatic transmission fluid (ATF). Dexron III (the fluid must have a G license). This is usually given as "Dexron III (G-xxxxx)"
where xxxxx is a 5 digit serial number. "Dexron III-G" (without a number) may also occur. The Volvo P/N for this oil is 1161521-8 (1 liter container).
Warning!
Avoid skin contact with the transmission fluid.
Conditions:
The oil should be replaced only in the two following instances:
Where diagnostic trouble codes (DTC's) TCM 0042 and TCM 0046 are stored, in which case the diagnostic function activates the warning lamp in the
following circumstances.
The transmission control module (TCM) receives data about the operating temperature of the transmission fluid while the car is being driven. TCM
0042 is stored after an accumulated amount of time.
Diagnostic trouble code (DTC) TCM 0046 is stored if the transmission fluid temperature exceeds 1500 C for more than two minutes. In cars used in
continuous taxi service or used for towing a trailer or caravan for most of its mileage, the oil must be replaced at a service interval of 75,000 km i
5000 km. This is to conform to the regular service program.
Warning!
The oil may be very hot if the car has just been driven. Avoid skin contact Draining
Remove:
-
the splash guard under the engine
-
the oil plug. Drain the transmission oil.
Installing the oil plug.
Use a new gasket.
Tighten the plug. Tighten to 40 Nm.
Install the protective cover.
Draining oil.
Remove the return hose on the control system cover.
