V70 2.4T L5-2.4L Turbo VIN 58 B5244T3 (2002)
Fluid - A/T: Removal and Replacement
Transmission fluid, replacing
Warning! Avoid skin contact with the transmission fluid.
Note! Use only transmission oil, Volvo P/N 116 1540-8 (1 liter container), 116 1640-6 (4 liter container).
Conditions
The oil should be replaced only in the two following instances:
Where diagnostic trouble codes (DTCs) TCM 0042 and TCM 0046 are stored, in which case the diagnostic function activates the warning lamp in the
following circumstances.
The transmission control module (TCM) receives data about the operating temperature of the transmission fluid while the car is being driven. TCM 0042
is stored after an accumulated amount of time.
Diagnostic trouble code (DTC) TCM 0046 is stored if the transmission fluid temperature exceeds 150° C for more than two minutes.
In cars used in continuous taxi service or used for towing a trailer or caravan for most of its mileage, the oil must be replaced at a service interval of 75,
000 km ± 5000 km. This is to conform to the regular service program.
Warning! The oil may beveryhot if the car has just been driven. Avoid skin contact.
Draining
Remove:
-
the splash guard under the engine
-
the oil plug. Drain the transmission oil.
Installing the oil plug
Use a new gasket.
Tighten the plug. Tighten to 40 Nm.
Install the protective cover.
Draining oil