Legend Coupe V6-3206cc 3.2L SOHC FI (1991)
Courtesy Light Controller: Technical Service Bulletins
Courtesy Light Controller - Replacement
YEAR
MODEL
BULLETIN NO.
1991
LEGEND LS
See VEHICLES
AFFECTED
May 20, 1991
BULLETIN NO. 91-028
Lower Dashboard Cover/Courtesy Light Controller Replacement
PROBLEM
The courtesy light controller cannot be removed from the driver's-side lower dashboard cover without damaging the cover or controller.
VEHICLES AFFECTED
Sedan:
through VIN JH4KA7 ... MC026438
Coupe:
through VIN JH4KA8 ... MC005668
CORRECTIVE ACTION
Use the following procedure to remove and reinstall the cover/controller.
Removal:
1.
Remove the lower dashboard cover's two lower mounting screws.
2.
Carefully pry the lower edge of the cover away from the dashboard, then forcibly remove the cover by breaking the knee bolster bracket.
3.
Lower the cover and disconnect the courtesy light controller connector. Push the controller from the rear while releasing its retaining clips with a
small flat tip screwdriver.
4.
Remove the broken knee bolster bracket and the courtesy light controller, then install a new knee bolster bracket (see PARTS INFORMATION).
Installation:
1.
If necessary, straighten the upper left mounting tab on the dashboard.
2.
Make sure the ignition switch grommet is positioned correctly, then insert the lower dashboard cover's upper right mounting clip into the slot in the
dashboard.
3.
Install all three cover screws finger-tight. While pushing the cover up and forward, tighten the upper left screw first, followed by the lower left