RL V6-3.5L (2007)
Brake Rotor/Disc: All Technical Service Bulletins
Brakes - Rear Brakes Squeal On First Few Applications
07-029
May 11, 2010
Applies To:
2005-07 RL - ALL
Rear Brakes Squeal
(Supersedes 07-029, dated June 19, 2007, to revise the information marked by the asterisks)
*REVISION SUMMARY
Under WARRANTY CLAIM IN FORMATION, the flat rate time was revised after the operation was reviewed and validated.*
SYMPTOM
The rear brakes squeal during the first few applications in the morning.
PROBABLE CAUSE
Improper brake pad material.
CORRECTIVE ACTION
Install new rear brake pads, and refinish the rear brake discs.
NOTE:
Do not use these replacement brake pads in areas where road salt* is used. They may not sufficiently remove the buildup of rust from the brake discs,
causing a scraping noise while braking, brake judder, or both. If rear brake squeal occurs in areas where road salt is used, continue with normal
troubleshooting.
*Road salt is commonly used in an area known as the "salt belt." The salt belt includes these states - Connecticut, Delaware, Illinois, Indiana, Iowa,
Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode
Island, Vermont, Virginia, West Virginia, and Wisconsin - and Washington D.C.
PARTS INFORMATION
Rear Brake Pad Set: P/N 43022-SJA-J00
WARRANTY CLAIM INFORMATION
The normal warranty applies.
Operation Number:
411842
Flat Rate Time:
0.9 hour
Failed Part:
P/N 43022-SJA-000