TL V6-3.5L (2007)
Canister Purge Control Valve: All Technical Service Bulletins
Emissions - Fuel Cap Warning ON/No DTC's Set
09-056
December 11, 2009
Applies To:
2007-08 TL - ALL
Fuel Cap Warning Message Is On Without DTCs
SYMPTOM
A TIGHTEN FUEL CAP message appears on the MID (multi-information display) without setting any Pending or Confirmed DTCs.
PROBABLE CAUSE
An intermittent fault in the EVAP canister purge valve causes the PCM on-board diagnostics for the evaporative emissions to fail.
CORRECTIVE ACTION
Replace the EVAP canister purge valve.
PARTS INFORMATION
EVAP Canister Purge Valve:
P/N 36162-RDV-J01
REQUIRED MATERIALS
WARRANTY CLAIM INFORMATION
In warranty:
The normal warranty applies.
Operation Number:
1201DO
Flat Rate Time:
0.2 hour
Failed Part:
P/N 36162-RDV-JO1
Defect Code:
03217
Symptom Code:
03203
Skill Level:
Repair Technician
Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone
Office. You must request consideration, and get a decision, before starting work.
DIAGNOSIS
With the fuel cap warning message on, check for DTCs with the HDS.
Are there any DTCs?
Yes - This service bulletin does not apply. Troubleshoot the DTC(s) as needed.
No - Go to REPAIR PROCEDURE.
REPAIR PROCEDURE
Replace the EVAP canister purge valve: