audi Workshop Repair Guides

Audi Workshop Service and Repair Manuals

ABOUT US
Using testers and measuring instruments during a road test > < Safety precautions

A1

Working on the fuel system
Working on the fuel system
When working on the fuel system note the following warnings:
  WARNING
Risk of injury - fuel system operates under pressure.
Wrap a cloth around the connection before opening the fuel system. Then release pressure by carefully loosening the connection.
The fuel can become extremely hot. This can cause injuries.
t  In extreme cases the temperature of the fuel lines and the fuel can be up to 100 °C after the engine is switched off. Allow the fuel to cool down before disconnecting the lines - danger of scalding.
t  Wear protective gloves.
t  Wear safety goggles.
Observe the following points to prevent personal injuries and damage to the injection and glow plug system:
t  Always switch off the ignition before connecting or disconnecting tester cables or electrical wiring for the injection or glow plug system.
t  Always switch off ignition before washing engine.
t  Faults are stored in the engine control units if electrical connectors were unplugged and the engine was started: Interrogate event memory in Guided Functions → Vehicle diagnostic tester.
  Caution
To prevent irreparable damage to the electronic components when disconnecting the battery:
t  Observe notes on procedure for disconnecting the battery.
t  Always switch off the ignition before disconnecting the battery.
Disconnecting battery → Electrical system; Rep. gr.27
   

Using testers and measuring instruments during a road test > < Safety precautions