audi Workshop Repair Guides

Audi Workshop Service and Repair Manuals

ABOUT US
Installing warning lamp for airbag deactivated on front passenger side K145 (from approx. week 23/2004 onwards) > < Removing front interior light W1 without warning lamp for airbag deactivated on front passenger side

A2

Installing front interior lightW1 with warning lamp for airbag deactivated on front passenger side (up to approx. week 22/2004)
Installing front interior light -W1- with warning lamp for airbag deactivated on front passenger side (up to approx. week 22/2004)
Special tools and workshop equipment required
   
t  Torque wrench -V.A.G 1783-
  Note
The wiring to the warning lamp for airbag deactivated on front passenger side -K145- (“PASSENGER AIRBAG OFF” lamp) is part of the front interior light -W1- wiring harness.
Installation is carried out in reverse order; note the following:
–  Plug in connectors for front interior light -W1- and, if applicable, for hands-free microphone.
–  Plug in connector for warning lamp for airbag deactivated on front passenger side -K145- (“PASSENGER AIRBAG OFF” lamp).
  W00-0990
–  Engage front interior light -W1- and secure -arrows-.
–  Press on reading light cover panel until it engages.
–  Switch on ignition.
  WARNING
Make sure nobody is in the vehicle when the battery is being connected.
–  Connect battery earth strap → Electrical system; Rep. Gr.27.
–  Observe measures to be taken after connecting the battery → Electrical system; Rep. Gr.27.
–  Re-code airbag control unit -J234- → Chapter.
–  Perform functional test.
–  Deactivate airbag on front passenger side with key-operated switch to deactivate airbag on front passenger side -E224-.
   Warning lamp for airbag deactivated on front passenger side -K145- must light up constantly.
–  Activate airbag on front passenger side with key-operated switch to deactivate airbag on front passenger side -E224-.
   Warning lamp for airbag deactivated on front passenger side -K145- must go out.
–  Interrogate and erase fault memories of all control units. To do so, use a suitable vehicle diagnostic, testing and information system, e.g. vehicle diagnostic, testing and information system -VAS 5051B-.
Tightening torque
  A96-0669
ComponentNm
Front interior light -W1- to roof3

   

Installing warning lamp for airbag deactivated on front passenger side K145 (from approx. week 23/2004 onwards) > < Removing front interior light W1 without warning lamp for airbag deactivated on front passenger side